电网建设施工作业指导书配网部分目录

ICS29.240中国南方电网有限责任公司电网建设施工作业指导书第8部分：配网工程中国南方电网有限责任公司组编ICS29.240内容提要为深入贯彻科学发展观，进一步提高电网工程建设施工质量水平，依靠技术创新和技术积累，不断提升公司电网建设整体技术管理水平和施工工艺科技含量，并便于组织电网工程施工从业人员进行培训，提高从业人员素质，确保电网工程施工质量，中国南方电网有限责任公司组织有关专家研究制定了《中国南方电网有限责任公司电网建设施工作业指导书》（以下简称《作业指导书》）。《作业指导书》在参照国家标准、行业标准、南方电网标准及相关的技术规范、规定的基础上，充分考虑了中国南方电网有限责任公司的实际情况，针对性、可操作性强。本套书分为输电线路、变电电气安装、变电土建、电气试验、继电保护、变电自动化、通信、配网工程分册。本书为《中国南方电网有限责任公司电网建设施工作业指导书第8部分：配网工程》分册，内容分为84个单项作业，包括：钢管杆、铁塔组立安装，钢筋混凝土杆组立安装，杆、塔拉线安装，横担、金具及绝缘子安装，跨越设施安装与拆除，导、地线展放，导、地线连接，紧线，金具及附件连接安装，电缆支架安装，电缆桥架安装，电缆敷设，冷缩电缆终端接头制作，热缩电缆终端接头制作，冷缩电缆中间接头制作，热缩电缆中间接头制作，电缆终端头接地及保护管安装，电缆鉴别，电缆防火封堵，室内油浸式电力变压器安装，干式电力变压器安装，箱式电力变压器安装，台架式电力变压器安装，固定式、手车式开关柜安装，环网开关柜安装，0.4kV低压开关柜安装，0.4kV低压硬（插接式）母线安装，户外断路器、负荷开关安装，户外隔离开关安装，户外互感器安装，户外避雷器安装，跌落式熔断器安装，高压计量装置安装，线路故障指示器安装，变压器试验，高压开关柜试验，环网柜试验，户外断路器、负荷开关试验，户外互感器试验，户外避雷器试验，电力电缆试验，接地网试验，直流屏安装及调试，二次电缆敷设及结线，继电保护调试，通信架空光缆安装，通信管道光缆安装，通信设备安装，通信电源装置安装，配网变压器监测计量终端安装，户内开关（环网）配电自动化终端安装，配网架空线路开关配电自动化终端安装，负荷控制终端安装，配网自动化通信安装，一般土石方工程，泥水坑及流砂坑开挖，岩石开挖，掏挖基坑开挖，杆塔基础工程，接地工程，电缆沟、槽盒，电缆管道，电缆井，电缆盖板，非开挖电缆管道，施工测量，基础开挖，地基处理，钢筋混凝土基础，基础防渗，钢筋混凝土框架结构，砌筑，墙面抹灰，门窗安装及其标识，屋面防水，预埋件制作与安装，楼地面，外墙面装饰，内墙面涂装，排水，通风与环境控制装置，防雷与接地，户内照明及开关、插座安装，消防、防火、防小动物封堵。本书适用于从事电网建设、施工、安装、验收、监理等的配网电气及土建专业工人、技术人员和管理人员使用，亦可供相关人员参考。编委会主任祁达才副主任徐达明邓恩宏赵曼勇编委陈晓明吴晖袁太平梁煜陈保刚周红阳李矛杨俊权闫国兵谭昌友王菁裴爱华评审组陈晓明吴晖袁太平丁晓兵陶文伟陈新南王菁罗楚楠马钦侯林高黄伟东廖元辉韦伟严启明赖荣先陈少强陈志辉王清良王仕龙马勇杨敏戴绍钧高绍兰江红春陈斌文睿主编单位中国南方电网有限责任公司基建部、系统运行部参编单位超高压输电公司广东电网公司广西电网公司云南电网公司贵州电网公司海南电网公司广东省输变电工程公司广东电网公司电力通信设备运维中心广东省电力科学研究院广东电力设计研究院广东火电工程总公司广东省电力一局广东合鸿达投资管理有限公司本册主要编写人员冼伟雄郭兴军黄健中马昌伟刘宇平冯振光萧丽景张志威钟志伟刘宇平陈国伟赵仲明龙华球黎永强宋桂彬原毅斌李志文胡霞林何风歧李文锋侯日富编制说明为贯彻落实中国南方电网有限责任公司“一体化”管理的思想，规范电网建设工程施工作业，公司基建部组织编写了《中国南方电网有限责任公司电网建设施工作业指导书》（以下简称《作业指导书》）。《作业指导书》按电压等级分为主网交流部分及配网部分，按专业特点细分为输电线路、变电土建、变电电气安装、电气试验、继电保护、变电自动化、通信、配网工程8个分册，共有208项作业指导，其中主网交流部分输电线路（包括高压电缆）、变电土建、变电电气、试验共124项（输电线路13项，变电土建28项，变电电气安装17项，电气试验27项，继保19项，自动化13项，通信7项）；配网部分84项（土建30项，电气45项，通信及自动化9项）。编写的内容按适用范围、编写依据、作业流程、工作前安全风险辨析与控制措施、作业准备、作业方法、质量控制措施及检验标准7个部分来编写，重点描述施工作业方法。安全风险辨析与控制措施依据《施工安全基准风险指南》，执行《安全施工作业票》，使安全措施在施工技术指导中更具可操作性。在质量控制措施及检验标准中引入WHS质量控制点，使作业人员更清楚本作业的质量关键控制点。考虑到施工作业技术的发展和设备材料的更新，今后将采用滚动修编的方式来不断完善作业指导书的内容和数量。《施工作业指导书》应用方法说明《施工作业指导书》应用步骤如下：第一步：筛选施工项目部在进行工程施工组织设计和编写专项施工方案时，从208份《施工作业指导书》中选择相应部分，形成工程项目的“《施工作业指导书》设置表”（附件1）并制作展示板布置于项目部。第二步：分析作业指导书中规定的施工流程、质量标准必须严格执行。施工项目部技术人员可针对设备材料、施工环境、安全因素等的具体情况，对需要调整或增补的作业方法在指导书原文上以“*”号进行标注，并将补充、完善的内容附在相应指导书后的分析表中（附件2）。第三步：审批工程项目具体使用的《施工作业指导书》需经监理审查并批准后方可应用于现场施工。第四步：应用1、作业准备：在现场作业前，依据作业指导书要求进行材料、人员、机具、场地准备，并进行现场安全文明施工布置。2、安全交底：施工负责人结合日站班会，对施工人员进行交底，落实安全风险控制措施。3、有序施工：作业人员严格按施工作业指导书流程要求进行施工、工艺控制。4、看板提醒：作业现场设置“作业指导书小看板”（简单的图形或表格），标识作业主要工艺流程、关键工序技术标准及安全风险辨识等。附件1：《施工作业指导书》设置表项目名称：施工单位：序号专业指导书名称指导书编号备注附件2：《施工作业指导书》分析表施工作业指导书名称施工作业指导书编号具体内容：目录编制说明《施工作业指导书》应用方法说明DLGT01钢管杆、铁塔组立安装作业指导书········································································1DLGT02钢筋混凝土杆组立安装作业指导书········································································9DLGT03杆、塔拉线安装作业指导书················································································17PWJX01横担、金具及绝缘子安装作业指导书····································································25PWJX02跨越设施安装与拆除作业指导书··········································································31PWJX03导、地线展放作业指导书···················································································37PWJX04导、地线连接作业指导书···················································································45PWJX05紧线作业指导书·······························································································51PWJX06金具及附件连接安装作业指导书··········································································59PWDL01电缆支架安装作业指导书···················································································65PWDL02电缆桥架安装作业指导书···················································································73DLFS01电缆敷设工程作业指导书····················································································81DLFJAZ01冷缩电缆终端接头制作安装作业指导书······························································93DLFJAZ02热缩电缆终端接头制作安装作业指导书····························································103DLFJAZ03冷缩电缆中间接头制作安装作业指导书····························································113DLFJAZ04热缩电缆中间接头制作安装作业指导书····························································121DLFJAZ05电缆终端头接地及保护管安装作业指导书·························································129DLJB01电缆鉴别作业指导书························································································137DLFHFD01电缆防火封堵作业指导书·············································································143DLBYQ01室内油浸式电力变压器安装作业指导书·····························································149DLBYQ02干式电力变压器安装作业指导书······································································157DLBYQ03箱式电力变压器安装作业指导书······································································165DLBYQ04台架式电力变压器安装作业指导书···································································171KGGAZ01固定式、手车式开关柜安装作业指导书·····························································179KGGAZ02环网开关柜安装作业指导书···