图解蒸汽疏水器原理

CopyrightTLVCo.,Ltd.1998.對蒸汽疏水器的介紹CopyrightDETTec.Co.,Ltd.1998.目录蒸汽疏水器的功能.蒸汽疏水器分类及工作原理热静力式.机械式.热动力式.蒸汽疏水器安装管例图蒸汽疏水器应用注意事项CopyrightDETTec.Co.,Ltd.1998.锅炉设备CopyrightDETTec.Co.,Ltd.1998.冷凝成水热交换锅炉设备蒸汽CopyrightDETTec.Co.,Ltd.1998.蒸汽的用途传递能量产品水加热蒸汽蒸汽放热水CopyrightDETTec.Co.,Ltd.1998.蒸汽疏水器的作用留住蒸汽排放冷凝水排放气体CopyrightDETTec.Co.,Ltd.1998.蒸汽疏水器的作用在起动时排放空气CopyrightDETTec.Co.,Ltd.1998.蒸汽疏水器的作用在起动时排放冷凝水CopyrightDETTec.Co.,Ltd.1998.蒸汽疏水器的作用留住蒸汽CopyrightDETTec.Co.,Ltd.1998.蒸汽疏水器的作用排放冷凝水CopyrightDETTec.Co.,Ltd.1998.蒸汽疏水器的作用留住蒸汽CopyrightTLVCo.,Ltd.1998.蒸汽疏水器的选用CopyrightDETTec.Co.,Ltd.1998.蒸汽疏水器的选用排放蒸汽主管的冷凝水蒸汽疏水器CopyrightDETTec.Co.,Ltd.1998.排放换热设备中冷凝水蒸汽疏水器的选用介质CopyrightDETTec.Co.,Ltd.1998.伴热管线蒸汽疏水器的选用CopyrightDETTec.Co.,Ltd.1998.伴热管线蒸汽疏水器的选用CopyrightDETTec.Co.,Ltd.1998.伴热管线蒸汽疏水器的选用CopyrightTLVCo.,Ltd.1998.热静力式疏水器双金属压力平衡CopyrightDETTec.Co.,Ltd.1998.双金属片冷热膨胀率高膨胀率低CopyrightDETTec.Co.,Ltd.1998.双金属片式疏水器工作原理冷热CopyrightDETTec.Co.,Ltd.1998.双金属片式蒸汽疏水器低温伴热管线仪表伴热在较低的固定温度CopyrightDETTec.Co.,Ltd.1998.双金属片式蒸汽疏水器大多数蒸汽疏水器很多闪蒸汽不能被利用CopyrightDETTec.Co.,Ltd.1998.双金属片式蒸汽疏水器双金属片式蒸汽疏水器没有闪蒸汽集留冷凝水直至冷却.优点:最大程度上利用了热能.缺点:有时会被误会.Nopointifcondensateutilizedcorrectly.集留冷凝水.CopyrightDETTec.Co.,Ltd.1998.双金属片式蒸汽疏水器双金属片式蒸汽疏水器换热器CopyrightDETTec.Co.,Ltd.1998.压力平衡疏水器伴热管线仪表伴热在接近蒸汽饱和温度下排放冷凝水小型工艺过程CopyrightDETTec.Co.,Ltd.1998.压力平衡式波纹管.膜片.CopyrightDETTec.Co.,Ltd.1998.压力平衡式:波纹管很薄的不锈钢酒精和水的混合物阀头CopyrightDETTec.Co.,Ltd.1998.压力平衡式:波纹管温度压力水蒸汽区水区填充液体液体在较低温度达到沸点.CopyrightDETTec.Co.,Ltd.1998.压力平衡式:波纹管CopyrightDETTec.Co.,Ltd.1998.压力平衡式:波纹管空气CopyrightDETTec.Co.,Ltd.1998.压力平衡式:波纹管冷的冷凝水CopyrightDETTec.Co.,Ltd.1998.压力平衡式:波纹管热冷凝水填充物沸腾波纹管膨胀疏水器关闭CopyrightDETTec.Co.,Ltd.1998.波纹管的缺点波纹管故障:金属疲劳.水锤.过热蒸汽.未知的故障模式:故障开或关.CopyrightDETTec.Co.,Ltd.1998.压力平衡式:膜片常见的外套1or2膜片填充液体阀头CopyrightDETTec.Co.,Ltd.1998.压力平衡式:膜片常见的膜片膨胀液体蒸发阀关闭CopyrightDETTec.Co.,Ltd.1998.压力平衡式:膜片常见的阀头不能密封蒸汽泄漏CopyrightDETTec.Co.,Ltd.1998.压力平衡式:膜片常见的疲劳易损点CopyrightDETTec.Co.,Ltd.1998.压力平衡式:膜片常见的故障关CopyrightDETTec.Co.,Ltd.1998.过热蒸汽会导致过膨胀.压力平衡式:膜片常见的膜片破损.CopyrightDETTec.Co.,Ltd.1998.MiyawakiX元件外套4到5片可延展膜片HASTALLOY®EQUIVALENT填充液体阀头420F不锈钢(Rockwell50C)CopyrightDETTec.Co.,Ltd.1998.MiyawakiX元件膜片支撑过膨胀保护可延展膜片防止膜片损坏CopyrightDETTec.Co.,Ltd.1998.MiyawakiX紧密关闭镜面抛光表面CopyrightDETTec.Co.,Ltd.1998.MiyawakiX元件锥形阀座排除了对不正的问题CopyrightDETTec.Co.,Ltd.1998.MiyawakiX元件保证是故障开!产品停止加热是危险的!!!!!在被发现之前会有一些蒸汽损失CopyrightDETTec.Co.,Ltd.1998.MiyawakiX元件故障开设计CopyrightDETTec.Co.,Ltd.1998.MiyawakiX元件故障开设计下面的膜片故障CopyrightDETTec.Co.,Ltd.1998.MiyawakiX元件故障开设计上面的膜片故障CopyrightDETTec.Co.,Ltd.1998.MiyawakiX元件故障开设计上面的膜片故障CopyrightDETTec.Co.,Ltd.1998.MiyawakiX元件系列•故障开.•密封好.•寿命长.•可更换膜盒.•硬化内件.•内置过滤网.•耐过热.CopyrightTLVCo.,Ltd.1998.机械式蒸汽疏水器CopyrightDETTec.Co.,Ltd.1998.机械式疏水器倒吊桶式.浮球式.CopyrightDETTec.Co.,Ltd.1998.倒吊桶式入口出口吊桶阀阀、杠杆支点排放孔CopyrightDETTec.Co.,Ltd.1998.倒吊桶式在起动时充满水CopyrightDETTec.Co.,Ltd.1998.倒吊桶式气体和空气到达疏水器CopyrightDETTec.Co.,Ltd.1998.倒吊桶式吊桶上浮CopyrightDETTec.Co.,Ltd.1998.倒吊桶式空气通过排放孔排除P1P1压头P1+压头速度慢CopyrightDETTec.Co.,Ltd.1998.倒吊桶式吊桶下沉空气排放CopyrightDETTec.Co.,Ltd.1998.倒吊桶式吊桶上浮空气排放慢CopyrightDETTec.Co.,Ltd.1998.倒吊桶式冷的冷凝水到达疏水器排放CopyrightDETTec.Co.,Ltd.1998.倒吊桶式蒸汽到达疏水器CopyrightDETTec.Co.,Ltd.1998.倒吊桶式吊桶上浮阀关闭不再流动CopyrightDETTec.Co.,Ltd.1998.倒吊桶式蒸汽冷凝TsTsTsTs温差小T速度慢CopyrightDETTec.Co.,Ltd.1998.P1压头P1+压头倒吊桶式蒸汽通过小孔排放CopyrightDETTec.Co.,Ltd.1998.倒吊桶式吊桶下沉蒸汽CopyrightDETTec.Co.,Ltd.1998.倒吊桶式吊桶下沉冷凝水CopyrightDETTec.Co.,Ltd.1998.倒吊桶式蒸汽进入疏水器冷凝水CopyrightDETTec.Co.,Ltd.1998.倒吊桶式吊桶浮起阀关闭CopyrightDETTec.Co.,Ltd.1998.倒吊桶式密封不好蒸汽泄漏集中磨损机械故障CopyrightDETTec.Co.,Ltd.1998.倒吊桶式可能发生的故障CopyrightDETTec.Co.,Ltd.1998.浮球式疏水阀连杆浮球式疏水阀自由浮球式疏水阀CopyrightDETTec.Co.,Ltd.1998.常见的杠杆浮球式疏水器浮球杠杆阀轴、支点空气排放阀CopyrightDETTec.Co.,Ltd.1998.常见的杠杆浮球式疏水器空气和气体排放CopyrightDETTec.Co.,Ltd.1998.常见的杠杆浮球式疏水器冷凝水空气排放阀关闭CopyrightDETTec.Co.,Ltd.1998.常见的杠杆浮球式疏水器冷凝水浮球上升阀打开CopyrightDETTec.Co.,Ltd.1998.常见的杠杆浮球式疏水器蒸汽浮球下落阀关闭不再流动CopyrightDETTec.Co.,Ltd.1998.常见的杠杆浮球式疏水器根据冷凝水的量自动调节CopyrightDETTec.Co.,Ltd.1998.杠杆浮球的优点在蒸汽饱和温度下工作.能根据冷凝水负荷的变化自动调节.快速排放空气.CopyrightDETTec.Co.,Ltd.1998.杠杆浮球的缺点.断裂集中磨损CopyrightDETTec.Co.,Ltd.1998.杠杆浮球的缺点阀和阀座之间存在集中磨损.波纹管会因为金属疲劳出现故障.CopyrightDETTec.Co.,Ltd.1998.自由浮球式疏水阀过滤网自由浮球阀嘴空气排放阀CopyrightDETTec.Co.,Ltd.1998.自由浮球疏水器工作原理空气CopyrightDETTec.Co.,Ltd.1998.自由浮球疏水器工作原理冷凝水CopyrightDETTec.Co.,Ltd.1998.自由浮球疏水器工作原理蒸汽关闭关闭水封CopyrightDETTec.Co.,Ltd.1998.自由浮球疏水器工作原理排放关闭打开CopyrightDETTec.Co.,Ltd.1998.自由浮球疏水器工作原理冷凝水CopyrightDETTec.Co.,Ltd.1998.自由浮球疏水器工作原理蒸汽关闭重新落回:新的浮球位置.CopyrightDETTec.Co.,Ltd.1998.排放蒸汽主管伴热管线浮球疏水器的选用CopyrightDETTec.Co.,Ltd.1998.机械式疏水阀总结耐水锤.及时排放连续排放.空气排放.寿命长.密封好.内置过滤网.???CopyrightDETTec.Co.,Ltd.1998.Miyawaki疏水阀（withSCCV系统）耐水锤.及时排放连续排放.空气排放.寿命长.密封好.内置过滤网.CopyrightTLVCo.,Ltd.1998.热动力式疏水器传统热动力疏水阀MIYAWAKI热动力式疏水阀CopyrightDETTec.Co.,Ltd.1998.传统热动力式疏水器CopyrightDETTec.Co.,Ltd.1998.传统热动力式疏水器CopyrightDETTec.Co.,Ltd.1998.冷的冷凝水流速慢传统热动力式疏水器CopyrightDETTec.Co.,Ltd.1998.热冷凝水压力下降PhiPlow传统热动力式疏水器CopyrightDETTec.Co.,Ltd.1998.闪蒸汽热冷凝水蒸汽流速快传统热动力式疏水器CopyrightDETTec.Co.,Ltd.1998.热冷凝水蒸汽流速快传统热动力式疏水器CopyrightDETTec.Co.,Ltd.1998.热冷凝水蒸汽流速快传统热动力式疏水器CopyrightDETTec.Co.,Ltd.1998.空气流速快上升CopyrightDETTec.Co.,Ltd.1998.热冷凝水压力增加传统热动