搜索
广东省公路工程施工表格(试行)第四册共四册第一册工程质量评定表第二册工程质量检验报告单及统计表第三册工程施工现场检查检测记录表第四册工程质量检验室内试验记录表主要编审人员：张代游罗炳华柴尔乔余峰广东省交通厅工程质量监督站一九九九年十月说明1、本套表格适用于广东省公路交通建设用，包括试验、检测、评定及施工检查检测原始记录。2、本分册试验表格包含目前公路工程常用的检查试验项目（室内），不包括非常规或不常用的试验。如锚具、伸缩装置、支座、桥梁荷载试验等。3、本表格的使用范围是指该材料拟用的单项工程名称。对于委托试验，送样单位为施工单位或其他有关部门。试验单位应将本套表格相关项目的全部记录表交付给送样单位，以备查验存档，不得只出报告结果。4、监理工程师应认真审核报告结果，并与规范设计值比较，然后签署比如“能否使用，用在何处”并签名的等具体意见。如果是监理工程师抽检平行校核试验，在监理工程师栏注明，并附上施工单位的自检报告。5、半刚性基层和水泥砂浆配合比强度试压报告未有专用表格，可参照相应的强度试验表格，但应注明是配合比设计。6、试验规程编号会可能修改，试验单位必须填写现行规程的编号。7、本表格编制得到了广东虎门技术咨询有限公司、广东省公路建设公司、广东省冠粤路桥有限公司、广东长大公路工程有限公司的大力支持。提出了很多宝贵的书面修改意见，在此表示感谢。8、由于时间仓促，和水平有限，难免有错漏，请将发现的问题和修改意见函告我站，以作修订时改进。一九九九年九月十日目录试验表（1）水质分析试验记录编号：·······································4试验表（2）水泥物理力学性能试验记录表编号：··········································5试验表(3)塑料排水板性能试验表编号：·········································6试验表(4)粗、细骨料含泥量试验记录表编号：·········································7试验表(5)碎石针、片状颗粒含量试验记录表编号：·········································9试验表(6)粗集料筛分试验记录表编号：·········································11试验表(7)细集料筛分试验记录表编号：·········································12试验表（8）集料视比重、松散容重及空隙率试验记录表编号：········································13试验表(9)压碎值试验记录表编号：········································14试验表（10）石料抗压强度试验记录表编号：········································15试验表（11）磨耗试验试验记录表编号：········································16试验表（12）粗集料磨光值试验记录表编号：········································17试验表(13)土颗粒组成分析(筛分法)试验记录表编号：········································19试验表（14）土颗粒组成分析(比重计法)试验记录表编号：········································20试验表（15）液限塑限联合测定试验记录编号：········································21试验表(16)承载比(CBR)试验记录表编号：········································23试验表(17)土壤膨胀量试验记录表编号：········································24试验表(18)重型击实试验记录表编号：········································25试验表（19）含水量试验记录表编号：········································26试验表(20)相对密度试验记录表编号：·········································27试验表(21)天然稠度试验记录表编号：·········································28试验表(22)室内回弹模量试验记录表编号：·········································29试验表(23)野外回弹模量试验记录表编号：·········································30试验表(24)标准砂标定试验记录表(灌砂法用)编号：·········································31试验表(25)半刚性基层(底基层)无侧限抗压强度试验记录表编号：······································33试验表(26)水泥或石灰剂量测定试验记录表编号：········································35试验表(27)回弹法测试原始记录表编号：·········································37试验表(28)结构或构件混凝土回弹强度计计算表编号：·········································39验表(29)水泥混凝土配合比设计计算表编号：·········································40试验表(30)水泥混凝土(砂浆)配合比设计强度记录表编号：·········································41试验表(31)水泥砼(砂浆)抗压抗折强度试验记录表编号：·········································42试验表(32)钢材力学性能试验记录表编号：·········································43试验表(33)钢材焊接力学性能试验记录表编号：·········································44试验表(34)预应力钢筋冷拉试验记录表编号：·········································45试验表(35)沥青三大指标试验记录表编号：·········································46试验表(36)沥青粘结力试验记录表编号：·········································47试验表(37)粘稠沥青含水量试验记录表编号：·········································49试验表(38)沥青粘度试验记录表编号：·········································50试验表(39)沥青加热损失试验记录表编号：·········································51试验表(40)沥青闪点和燃点试验记录表编号：·········································52试验表(41)沥青混合料含量及混合料筛分记录表编号：·········································53试验表(42)沥青混合料马歇尔试验记录表编号：·········································54试验表(43)沥青混凝土沥青用量选定图编号：·········································55试验表(44)沥青混凝土芯样密实度试验记录表编号：·················57试验表（1）水质分析试验记录编号：项目名称施工单位合同段取样地点水源状况试验日期使用范围试验单位试验规程编试验项目取样体积(m1)试剂浓度(N)滴定量毫克当量/升mg/L毫克当量％备注初读终读消耗量游离CO2侵蚀性CO2COHCOCL-SO阴离子总量Ca2+Mg2+总硬度Na++K+阴离子总量PH值23324总碱度自检意见监理意见试验记录计算复核质检负责人项目主管试验表（2）水泥物理力学性能试验记录表编号：项目名称合同段施工单位取样地点使用部位水泥标号试验日期厂牌种类试验规程编号试验单位软练标号1350g砂+540g水泥+238g或248g水3天龄期7天龄期28龄期细度荷载KN强度MPa平均值MPa荷载KN强度MPa平均值MPa荷载KN强度MPa平均值MPa样品重=克残余重=克细度==抗折抗压安定性描述1．弯曲2．开裂3．正常凝结时间500g水泥加水时间：年月日时分第一次加水量142．5g沉入度mm稠度％第二次加水量g沉入度mm稠度％第三次加水量g沉人度mm稠度％序号时间读数序号时间读数序号时间读数残余重样品重样品111222333444555初凝时间：时分终凝时间：时分自检意见监理意见试验记录计算复核质检负责人项目主管试验表(3)塑料排水板性能试验表编号：项目名称施工单位取样地点合同段试验规程编号排水板产地试验单位排水板型号拟用区段试验日期外观检测项目试样编号备注123456平均纵向通水量(cm3/s)滤膜渗透系数(cm3/s)复合体抗拉强度(干态)(KN/10cm)滤膜抗拉强度(N/cm)纵向干态横向湿态滤膜等效孔径(μm)自检意见监理工程师意见：试验记录计算复核质检负责人项目主管试验表(4)粗、细骨料含泥量试验记录表编号：项目名称深汕高速公路西段长沙湾软基路段补强工程合同段施工单位广东能达高等级公路维护有限公司取样地点试验规程编号试验日期使用范围试验单位试样编号试验前的烘干试样重量(克)试验后的烘干试样重量(克)含泥量(％)备注①②③=×100①-②①自检意见：监理意见：试验记录计算复核质检负责人技术主办试验表(5)碎石针、片状颗粒含量试验记录表编号：项目名称深汕高速公路西段长沙湾软基路段补强工程合同段施工单位广东能达高等级公路维护有限公司取样地点使用范围试验规程编号JTJ058-2000试验日期样品重试验单位粒级(mm)水泥砼5-1010-1616-2020-2525-31.531.5-40合计沥青面层5-1010-1616-2020-2525-3030-60各级筛余重(g)各级针状颗粒重(g)各级片状颗粒重(g)针片状总含量百分率(％)备注：自检意见监理意见试验记录计算复核质检负责人技术主办试验表(6)粗集料筛分试验记录表编号：项目名称深汕高速公路西段长沙湾软基路段补强工程合同段施工单位广东能达高等级公路维护有限公司取样地点使用范围试验日期样品名称试验规程编号JTJ058-2000试验单位试样重量(g)筛孔尺寸(mm)分计筛余重量(g)分计筛余(％)累计筛余(％)通过量(％)规范值(％)12平均筛分曲线图自检意见监理意见试验记求计算复核质检负责人项目主管通过百分率（%）累计筛余百分率（%）筛孔尺寸(mm)试验表(7)细集料筛分试验记录表编号：项目名称深汕高速公路西段长沙湾软基路段补强工程合同段施工单位广东能达高等级公路维护有限公司取样地点样品名称试验日期使用范围试验规程编号JTJ058-2000试验单位试样重量(g)筛孔尺寸(mm)分计筛余重量(g)分计筛余(％)ai累计筛余(％)Ai通过量(％)Bi规范值(％)水泥砼(圆孔)沥青面层(方孔)12平均109.554.752.52.361.251.180.6