TE441网络控制系统电缆表

株所CDC-16(08-475)捣稳车网络控制系统电缆表箱号（模块号）电缆号电缆型号起始端信号（颜色）端子号终端名称Signal代号长度备注B44.1OY2x0.5前左扶梯灯按钮盒1b1407B4-前端输入控制箱第1页，共44页B44.1OY2x0.5前左扶梯灯按钮盒1b140711AL3134.2OY2x0.5前右扶梯灯按钮盒1b141511AL3134.3OY2x0.5前门旁灯开关1b33671常开AL314.4OY2x0.5前小车解锁阀1s1004V41+前左1V41+前左1V192-4.5OY2x0.5前小车下降阀1s1084V61+前左2V292-4.6OY2x0.5前小车左锁定行程开关1b16341常开V604.7OY2x0.5前小车右锁定行程开关1b1643V60常开V594.8OY2x0.5距离测量盒B615S+OD34.9OY2x1.0前下雨刮电机1m2051L514.10OY2x0.5喷水马达1m1951L50.====L54B4,B11短接,短接4.11OY2x1.0司机室照明1h951L494.12OY2x1.0前左工作灯1h3551L484.13OY2x1.0前右工作灯1h6541L48414OY2x10前铁路信号灯1h6654.14OY2x1.0前铁路信号灯1h6651L484.15CY2x1.5激光发射箱插头1u7171(1)国产-BL(2)国产+4.16OY2x1.0左侧面长日光灯1h21351AL154.17OY2x0,5右侧面长日光灯411AL154.18NFL4x0.5距离测量箱B615E6714E688E696S22104.19NFL4x0.5激光接受靶感应开关1f1394S21(+)XDA2(感应)OD3(-)4.20自带线激光接受靶1u625E7H----黑E8K----灰/粉红E9V----红/棕E10C----灰E11A（注A与T短接）（A--红T---白/兰）E12D----绿E20N----白/灰E21L----白/绿E22P----灰/棕第1页，共44页株所CDC-16(08-475)捣稳车网络控制系统电缆表ODB(B与E,G,J短接)(B-兰,E-黄,G-棕,J-棕/兰)4.21OY7x0.5前小车左开关盒1X166/167/b34X166LI(左){X166.OD}第2页，共44页X166LI(左){X166.OD}X167RE(右){X167.OD}3组均接常开V29HE(提升){V29.1}OD14.22OY7x0.5前小车右开关盒1X166/167/b34X166LI(左){X166.OD}X167RE(右){X167.OD}3组均接常开V29HE(提升){V29.1}OD114.23OY2x1.5B112E544.24OY18x0.5发动机前控制箱B112SP7Si30Si33L7(用双线)L6(用双线)(用线)L18(用双线)3144.25CY4x0.5B4815NPSCSTD.3-13201bSTD.3-14201cSTD.3-154.26OY10x0.5B112X166X167X167XDAV59XC3FP2J26.2采集NPKNPS4.27GOUEF6OD接地24.28GOUEF101接地2429GOUEF44.29GOUEF4OD3接地24.30GOUEF4记录仪接地1自带线激光发射靶插头连线1白2棕4.31GUOEF35TGCS-CAN地线1OD记录仪1Rg1记录仪g记录仪电源B4自带线S101自带线B4E68白E69棕ODB61-距离脉冲传感器接线箱B61611CY6x025距离脉冲传感器1f515B6161.1CY6x0.25距离脉冲传感器1f5152绿7白15棕w5黄3（屏蔽）B11-前司机室控制箱B1111.1OY2x0.5ZF制动压力开关1b133511G3311.2OY2x0.5制动灯压力开关1b595第2页，共44页株所CDC-16(08-475)捣稳车网络控制系统电缆表11L21X543311.3OY2x0.5脚踏开关1b418L41第3页，共44页L211.4OY2x0.5高音阀1s22071L41注：在B11箱中将L41与L42短接11.5OY2x0.5低音阀1s21971L42注：在B11箱中将L41与L42短接11.6OY4x0.5风喇叭接近开关1b4207L2+1L40A41-311.7OY2x1.5前警灯1h5571L2811.8OY2x1.5电喇叭1h1671L2911.9OY2x0.5喷水马达1m357喷1L5411.10OY2x1.5前顶大灯1h2281L2611.11OY2x1.5前左搜索灯1h1231L2511.12OY2x1.5前右搜索灯1h1151L2711.13OY2x1.5插座51SV411.14OY2x0.5左风扇1m3841L711.15OY2x0.5右风扇1m3951L711.16OY4x0.5仪表照明2L99L991111.17OY4x0.5前左停机盒1b8/203L18HT(喇叭){L18,1}常开Si80,==X1BDSi81MST(喇叭){Si80,Si81}常闭111.18OY4x0.5前右停机盒1b9/215L18HT(喇叭){L18,1}常开Si82Si81MST(喇叭){Si80,Si81}常闭131311.19OY4x0.5前左标志灯箱1h45/50L23RL(标志灯){L23,1}标志灯在上L22BRL(制动灯){L22,1}制动灯在下1111.20OY4x0.5前右标志灯箱1h44/515L24RL(标志灯){L24,1}标志灯在上L22BRL(制动灯){L22,1}制动灯在下第3页，共44页株所CDC-16(08-475)捣稳车网络控制系统电缆表1111.21OY4x1.5上部雨刮电机1m345L5253第4页，共44页L5331BL553A13111.22OY18x0.5前后连接控制箱B4815L9STD.2-19L30STD.2-20L31STD.2-21L32STD.2-22L33STD.2-23L34STD.2-24L35STD.2-25L36STD.2-26L37STD.2-27L38STD.2-28L39STD.2-29L21STD.2-34262STD.2-3711.23OY16x1.5前后连接控制箱B4815前后接控制箱A26STD.6-19Si82Si84DK314STD.1-7L2STD.6-8L18STD.6-9L28STD.6-10L40STD.6-11L41STD.6-12L42STD.6-13L55STD.6-14201aSTD.6-22Z1STD.6-23STD.1-C1611.24GUOEF10111.25OY2x1.0作业椅打气泵1m4021L811.26OY2x1.0行车椅打气泵1m4121L811.27OY2x0.5旁路制动阀2201a111.28OY2x0.5电控阀2Z1111.29OY2x0.5前大闸2FV常开Z111.30OY7x1.5B2612G6XC6、XC8短接G44XC7、XC9短接11131OY7x05B231211.31OY7x0.5B2312G6与G5短接G7G4NPS11.32GOUEF6OD接地211.33GOUEF101接地2第4页，共44页株所CDC-16(08-475)捣稳车网络控制系统电缆表B13发动机控制接线箱13.1OY2x0.51轴闸瓦报警开关1b4761常开A8第5页，共44页13.2OY2x0.52轴闸瓦报警开关1b47a41常开A813.3OY2x0.5总风压力开关1b10661A1213.4OY2x0.5发动机滤清器11b11031A613.5OY2x0.5发动机滤清器21b11131A713.6OY2x0.5小柴油箱油位开关(600ml)1b715511柴油箱A13313.8OY2x1.5吸油电动泵1m427HP+柴油箱11-13.9OY4x1.0干燥剂控制盒B56102082wa55干燥剂指示灯wa66干燥剂指示灯干燥器自带线1113.10OY2x1.5加热电阻1r1注：换向阀插头更换成带续流二极管型20813.12AF-250.1.5发动机插座1b74/14/916A4Temp.Sch发动机温度开关A21Temp.Geb发动机温度传感器245Kerzenm.喷油阀预热指示灯信号AF-250.1.5313M-Stop停机阀1s6/5206aStarth辅助起动阀AF25040242K预热赛AF-250.4.0242Kerze.预热赛13.13AF-250.1.5发动机油压传感器+开关1f186A22Geb.GA56Sch.0.5Bar白头A57Sch.2.5Bar红头13.14AF-250.1.5发动机油温开关1b736A5窄头13.15AF-250.1.51，2#发动机输出信号1m9/1061A14D+(大发电机)1A14D(大发电机)1A15D+(小发电机)1WW(1m10)13.16AF-250.1.53#发动机输出信号1m2151A16D+(小发电机)13.17AF-250.2.5起动马达线圈1m85206a113.18GUOEF95起动马达1m811车体接地1车体接地13.19OY4x0.5油位开关1f446233323521113.20CY4x0.5里程传感器1G35A34+A33脉冲1-13.21BETA50发动机1m96e113.22BETA50发动机1m92第5页，共44页株所CDC-16(08-475)捣稳车网络控制系统电缆表1车体接地13.23BETA35发动机1m106e213.24BETA35发动机1m92第6页，共44页发动机1车体接地13.25BETA35发动机1m216e313.26BETA35发动机1m921车体接地13.27GUOEF35电瓶1n22e713.28GUOEF35电瓶1n211车体接地车体接13.29GUOEF50应急泵控制箱B914e513.30GUOEF95电瓶1n13TA113.31GUOEF95电瓶启动电机1m811n13013.32GUOEF95电瓶1n111车体接地13.33GUOEF35紧急停止控制箱B954紧停控制箱e6d213.34OY16x0.5前后连接控制箱B4815Wa5STD.2-35Wa6STD.2-36208STD.2-15b23234STD.2-2238STD.2-3261DKA9DK供油系统A10STD.8-A1A11STD.3-1A33STD.3-6A34STD.3-7A40STD.2-913.35OY16x1.5前后连接控制箱B4815201STD.1-1204STD.1-2206STD.1-3243STD.1-4244STD.1-5245STD.1-6B+STD.6-17SV4STD.6-16FP1STD.6-15WSTD.6-2113.36OY3x4前后连接控制箱B4815H+3STD.5-313.37GUOEF10前后连接控制箱B4815FHSTD.5-213.38OY2x1.5模块控制箱B74S213.39OY4x1.5上中位置作业控制箱B257S2A26M6213.40GUOEF4上中位置作业控制箱B257M4113.41OY7x1.5右上位置作业控制箱B248K30空调截流阀电ZS10集中润滑系统N2A41s213.42OY10x1.5前输入控制箱B48BLC+S+第6页，共44页株所CDC-16(08-475)捣稳车网络控制系统电缆表FP1201N213.43OY18x0.5发动机前控制箱B1110第7页，共44页发动机前控制箱250A3A4A5A6A7A8A12A13A14A15A16A9A10A11Wa5Wa613.44OY16x1.5发动机前控制箱B1110机201204206215243244245A33A34A26B+SV4L7W13.45GUOEF10发动机前控制箱B1110FV13.46OY4x1.5B954Si4513.47GUOEF4紧急停止控制箱B95