搜索
钢丝绳电动葫芦检测报告Testreportofwire-ropeelectrichoistJB/T9008.1—2004JB/T9008.2—2004规格型号CD10t-18mspecificationandtype出厂编号11067703ManufacturingCode工作级别M3workgrade检验日期2012年06月inspectiondate保定维佑商贸有限公司BaodingWeyouTechnologyCompany钢丝绳电动葫芦检验记录Testrecordofwire-ropeelectrichoist序号No.考核项目Inspecteditem单位unit质量指标Qualitystandard检验结果Testresult结论conclusion备注remark1静载试验Statictestt试验载荷testload:1.25Gn符合要求合格2动载试验Dynamictestt试验载荷testload:1.1Gn符合要求合格3降压试验Reducedpressureexperiment—90%额定电压试验载荷1.0Gn90%ratedvoltagetestload1.0Gn(Gn为额定载荷Gnisratedload)符合要求合格4起升速度Liftingspeedm/min偏差为名义值的±10%Warpis±10%ofnormalvalue.6.9m/min合格5起升高度Liftingheightm偏差为名义值的-3%Warpis-3%ofnormalvalue.17.92m合格6制动下滑量Brakeslidequantitymm试验载荷testload1.0G制动下滑量brakeslidequantityS≤V/100(V为1分钟内实测吊钩稳定上升的距离Vistestedhookhoistingdistanceinoneminute)16mm合格7起升机构噪音NoiseofliftingmechanismdB(A)试验载荷1.0Gn时(whentestloadis1.0Gn)0.25t~5t≤85,5t以上≤9072合格8电动小车空载噪音zeroloadnoiseofelectrictrolleydB(A)≤8071合格9电动小车爬坡试验climbingtestofelectrictrolley—坡度不小于1/200gradientnotlessthan1/200试验载荷testload:1.0Gn符合要求合格10运行速度Travelingspeedm/min偏差为名义值的±15%Warpis±15%ofnormalvalue.————11导绳器Rope-guide—装配合理,空钩下降时,钢丝绳应能自由地从导绳器的出口排出.Reasonableassembly,whenhookwithoutloaddescends,wireropeshouldbeputoutfreelyfromtherope-guide.能自由排出合格12限位器limiter—限位开关动作可靠Limitswitchshouldactreliably.可靠合格13钢丝绳Wirerope—有合格证且绳端固定牢靠,编绕正确.Havingcertificateofapprovalandropeendisfixedreliably.正确合格14防护等级Protectiongrade—IP44IP44合格钢丝绳电动葫芦检验记录Testrecordofwire-ropeelectrichoist15绝缘电阻InsulationresistorMΩ＞1.5480合格16接地电阻EarthresitorΩ＜0.10.01合格17起升减速器内杂物sundriesinhoistingreducermg≤250≤191合格18油漆漆膜厚度Paintfilmthicknessμm油漆漆膜总厚度不小于50generalthicknessofpaintfilmisnolessthan50(取10处平均值getmeanvaluefromtenplaces’value)54合格19漆膜附着力Adhesionofpaintfilm—应符合GB9286的规定AccordwiththeregulationsofGB9286符合规定合格20升压试验Liftingpressuretest—110%Ue.1.0Gn载荷,电动机和电器装置无异常When110%Ue.1.0Gnload,thereisnoabnormalphenomenonwiththemotorandelectricappliance.无异常合格21起升机构用减速器的箱体盖中心距偏差centerdistancewarpofbodycoverofreducerinliftingmechanismmm≤±0.09≤-0.02合格22钩口变形Mouthofhookdistortion%钩口变形量不大于0.25%Deflectionquantityofhookmouthisnotmorethan0.25%.0.02%合格23电气设备Electricequipment—检查是否有合格证和质检中心型式报告.Checkifthereisanycertificateofapprovalandqualityinspectionreport.有合格检验结论testconclusion:经检验各项指标符合标准要求经检验各项指标符合JB/T9008.1—2004、JB/T9008.2—2004标准要求Afterinspection,allindexaccordwithstandardrequirements.检验员:审核:签发日期:年月inspector:review:signaturedate: